Safety data sheet

LINSEED OIL VARNISH for maximum temperature and pressure stability
Product number AIS B020

Safety data sheet conforming to Regulation (EU) No 453/2010
LINSEED OIL VARNISH

The information provided here is based on our knowledge and experience at the current time. The safety data sheet sets out the safety requirements relating to our product and does not constitute a warranty of any particular properties. It is the responsibility of the consignee of our product to observe the existing laws and regulations.

SECTION 1: Identification of the substance / mixture and of the company / undertaking

1.1. Product identifier:
Registered trade name: LINSEED OIL VARNISH

1.2. Relevant identified uses of the substance or mixture and uses advised against
Usage: For mixing with the product BIRKOSIT Dichtungskitt® at a ratio of 1:10

1.3. Details of the supplier of the safety data sheet
Company: A.I. Schulze Chemotechnische Fabrik e.K.
Address: Johannes-Robert-Becher-Straße 39, 02827 GÖRLITZ, GERMANY
Contact: Tel. +49 3581 75005-0 Fax +49 3581 75005-20
email: management@a-i-schulze.com

1.4. Emergency telephone number
Emergency information service: Tel. +49 3581 75005-10  (24h)

SECTION 2: Hazards identification

2.1. Classification of the substance or mixture
Not required.

2.2. Label elements
The product does not meet the criteria for classification under EC Directives.

2.3. Other hazards
None.

SECTION 3: Composition / information on ingredients

3.2. Mixtures
The product contains the following relevant components:

CAS no.NameREACHEEC no.Index no.SymbolsR phrases
68649-95-6Linseed oil varnish
CAS no.68649-95-6
NameLinseed oil varnish
REACH
EEC no.
Index no.
Symbols
R phrases

SECTION 4: First aid measures

4.1. Description of first aid measures
General information: Change any clothing which has been soiled with the product.
In case of ingestion: Seek fresh air and consult a doctor if symptoms persist.
In case of skin contact: Wash off with plenty of soap and water.
In case of contact with eyes: Hold eyelid open and rinse the eye out under running water for several minutes. Consult a doctor if irritation persists.
If swallowed: Rinse out mouth and then drink plenty of water. Consult a doctor if symptoms persist.

4.2. Most important symptoms and effects, both acute and delayed
No known symptoms and effects to date.

4.3. Indication of any immediate medical attention and special treatment required
No known special measures to be taken other than the treatment of symptoms.

SECTION 5: Firefighting measures

5.1. Extinguishing media
Suitable extinguishing media: Carbon dioxide (CO2), extinguishing powder or water spray jet. Use water spray jet or alcohol-resistant foam to fight larger fires.
Unsuitable extinguishing media: Full water jet.

5.2. Special hazards arising from the substance or mixture
Carbon monoxide (CO), carbon dioxide (CO2) and acrolein

5.3. Advice for firefighters
The product has a tendency to self-ignite if absorbed by e.g. sawdust, clothing or insulating materials. Risk of self-ignition of finely dispersed hot particles.
Special protective equipment: put on breathing apparatus.
Collect contaminated water separately and do not allow into the drainage system.

SECTION 6: Accidental release measures

6.1. Personal precautions, protective equipment and emergency procedures
Avoid contact with the skin and eyes.

6.2. Environmental precautions
Take measures to prevent leakage into the drainage system / surface water / groundwater.

6.3. Methods and material for containment and cleaning up
Absorb any spillages with inert material (sand, infusorial earth). Do not use combustible material, e.g. sawdust. Dispose of contaminated waste as instructed in section 13.

6.4. Reference to other sections
See section 13.

SECTION 7: Handling and storage

7.1. Precautions for safe handling
Avoid contact with the skin and eyes.
Finely dispersed hot particles have a tendency to self-ignite. Keep away from sources of ignition – do not smoke.

7.2. Conditions for safe storage, including any incompatibilities
Requirements relating to storage areas and containers: Comply with water law requirements.
Instructions on storage alongside other materials: Store separately from oxidising agents.
Further instructions on storage conditions: None.

7.3. Specific end uses
No further recommendations.

SECTION 8: Exposure controls / personal protection

8.1. Control parameters
No further measures required over and above those set out in section 7.

8.2. Exposure controls
Individual protection measures, such as personal protective equipment:
Avoid contact with the eyes and skin. Wash hands before breaks and at the end of work.

Respiratory protection: Not required in well ventilated areas.
Hand protection: Protective gloves. The gloves must be made of impermeable material which is resistant to the product / substance / preparation.
No recommendations can be made as to the best glove material for the product / preparation / chemical mixture as no tests have been carried out. The suitability of a glove does not only depend on the material but on other quality criteria as well, and varies from manufacturer to manufacturer. The glove manufacturer is to be consulted about the exact protective life of the gloves.
Eye protection: Safety glasses.

SECTION 9: Physical and chemical properties

9.1. Information on basic physical and chemical properties
Form: Liquid
Colour: Amber
Odour: Mild

9.2. Other information
Melting point / freezing point: -10 °C
Initial boiling point and boiling range: Not specified
Flash point: 320 °C
Ignition temperature: 300 °C
Explosion hazards: The product does not present an explosive hazard
Vapour pressure at 20 °C: 1 hPa
Density at 20 °C: 0.94 – 0.95 g/cm³
Solubility in / miscibility with water: Non-miscible or low miscibility

SECTION 10: Stability and reactivity

10.1. Reactivity
Not relevant.

10.2. Chemical stability
Stable.

10.3. Possibility of hazardous reactions
Finely dispersed hot particles have a tendency to self-ignite.

10.4. Conditions to avoid
No decomposition if used as specified.

10.5. Incompatible materials
Strong oxidising agents.

10.6. Hazardous decomposition products
Carbon monoxide (CO), carbon dioxide (CO2) and acrolein.

SECTION 11: Toxicological information

11.1. Information on toxicological effects
LD/LC50 data relevant to classification:
Oral LD50 4986 mg/kg (rat)
Primary irritation:
On the skin: No irritant effect.
On the eyes: No irritant effect.
Sensitisation: No known sensitising effect.
Other toxicological information: In our experience and according to our information, the product has no adverse effects on health if used and handled as instructed and as specified. 

SECTION 12: Ecological information

12.1. Toxicity
Do not allow product to leach into the environment. Decant and treat contaminated waste water before it is discharged into the drainage system.

12.2. Persistence and degradability
Not relevant.

12.3. Bioaccumulative potential
Not relevant.

12.4. Mobility in soil
Not relevant.

12.5. Results of PBT and vPvB assessment
Not relevant.

12.6. Other adverse effects
Water hazard class WK 1 (slightly hazardous to waters) (according to VwVwS publication dated 17.05.1999, formerly WK 0 which has now ceased to exist).

SECTION 13: Disposal considerations

13.1. Waste treatment methods
Do not dispose of the product with household refuse. Do not allow product to leach into the drainage system.
Waste code number: The waste code number according to the Ordinance on the European Waste Catalogue (AVV) depends on the waste producer and can therefore vary for any given product. The waste code number is therefore to be gleaned separately from each waste producer.
Contaminated packaging: Dispose of as directed by the authorities.

SECTION 14: Transport information

There are no specific precautions to be taken. Not classed as hazardous goods under the above ordinances.

14.1. UN number
    

14.2. UN proper shipping name
    

14.3. Transport hazard classes
    

14.4. Packing group
    

14.5. Environmental hazards
    

14.6. Special precautions for the user
    

14.7. Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code
    

SECTION 15: Regulatory information

15.1. Safety, health and environmental regulations / legislation specific for the substance or mixture
Labelling under EEC Directives: The substance does not meet the criteria for classification according to EC lists or other reference sources known to us. The standard precautions for the handling of chemicals are to be taken.

National regulations:
Major Accidents Ordinance (StörfallV): Hazardous incident reporting ordinance, annex: Not stated.
Water hazard class: Water hazard class 1 (listed classification): Slightly hazardous to waters, code number: 768.

15.2. Chemical safety assessment
Not relevant.

SECTION 16: Other information

The information is based on our knowledge at the current time. The safety data sheet does not constitute a guarantee of any product properties nor does it establish a legal contractual relationship.

Safety data sheet as at 02.09.2013.